Short Communication

 

 

Effect of Pre-Warming on Broiler Breeder Eggs Hatchability and Post-Hatch Performance

 

Adnan Yousaf1*, Adnan Jabbar1, Yasir Allah Ditta2

Sadiq Poultry (Pvt.) Limited, Chakri Hatchery Rawalpindi, Pakistan, 2Department of Animal Nutrition, University of veterinary and Animals Sciences Lahore

 

Editor | Asghar Ali Kamboh, Sindh Agriculture University, Tandojam, Pakistan.

Received | October 05, 2016; Accepted | January 08, 2017; Published | January 12, 2017

*Correspondence | Adnan Yousaf, Sadiq Poultry (Pvt.) Limited, Chakri Hatchery Rawalpindi, Pakistan; Email: dr.adnan011@gmail.com

Citation | Yousaf A, Jabbar A, Ditta Y.A (2017). Effect of pre-warming on broiler breeder eggs hatchability and post-hatch performance. J. Anim. Health Prod. 5(1): 1-4.

DOI | http://dx.doi.org/10.14737/journal.jahp/2017/5.1.1.4

ISSN | 2308–2801

Copyright © 2017 Yousaf and Jabbar. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

 

Poultry is the 2nd largest industry of Pakistan whose play a dynamic role in the GDP of country. Poultry products are rich source of protein and good source of income. Importance of poultry is further emphasized by its demand and production ability in the country (Hussain et al., 2015; FAO, 2011). In Pakistan, currently there are more than twenty-five thousand poultry farms and four hundred hatcheries, that providing employment and income for livelihood of thousands of people and also fulfilling the most of animal protein requirement of the nation. Moreover, the poultry industry has engaged a thousands of veterinarians for disease management and quality insurance of poultry products (Anonyms, 2011; Nazia et al., 2015).

 

Temperature is the main factors known to influence embryonic development (Mahmud et al., 2011). The effect of pre-heating on hatchability has been evaluated to a partial developmental stage of embryo before or after pre-heating treatment (Reijrink et al., 2009). It is of interest to point out that, prior storage, heating the chick eggs for six hours allowed the complete formation of hypoblast (Silva et al., 2008). The effects of pre incubation on hatchability are directly depending upon their flock management, nutrition, age and pre-heating temperature/period. It was documented that the chick weight, hatchability and temperature are very closely interrelated (King’ori, 2011). Development of embryo in broiler breeder eggs are started from the time of laying, as at the moment of lay, the egg temperature is above 40°C (North and Bell, 1990). In the recent decades, several studies reported that pre-heating of poultry eggs before storage resulted in more live chicks and a lower level of embryonic mortality compared to the eggs that remained un-heated (Reijrink et al., 2009). Temperature is the mainly critical aspect in hatching egg management as temperature affects embryo growth. Pre-warming of hatching eggs enhanced to incubation through prevention of condensation and reduction of variation in egg shell temperatures (Koka, 2002). The pre-warming process straightly influence embryo capability, as it might affect cell death especially when cell viability is reduced after prolonged storage (Koka, 2002). The purpose of this study was to investigate the effect of pre-warming regimen on broiler eggs hatchability and post-hatch performance of chicks.

 

Material and Methods

 

Selection of Site

 

The current study was performed at Sadiq Poultry (Pvt) Limited, Chakri Hatchery Rawalpindi, Pakistan, one of the largest commercial broiler hatchery of Asia.

 

Eggs Selection and Classification

 

Eggs (wt. 53-60 g) from broiler breeders (Ross 308, 45-50 weeks of age) were classified into three groups, such as A, B and C. Group C was served as control, while rest of two groups were treated with different duration of pre-warming in commercial single stage setters (Avida G4, Chick Master USA). Hatchable eggs were selected on the basis of shell quality, weight and color. Only oval shape good quality intact eggs were selected for hatching. The substandard eggs such as cracked, misshapen, blood-stained, dirty, toe-punched and elongated were rejected (Khan et al., 2016). These eggs were collected at farm and stored at 20°C and 75% relative humidity until used in hatching trail. Before, trail eggs were fumigated with 20 g KMnO4 and 40 ml formalin (40%), and 40 ml of water for 100 ft3 area for 15 minutes.

 

Pre-Warming Regimen

 

Each experimental group was consisting of 4,03,920 eggs. Group C (Setter) was served as control group, while group B was pre-heated at 82 oF for 3 hours and group A pre-heated at 82 oF for 5 hours inside incubators. After completion of pre-heating stage the incubator started automatically stage profile (Ross prime age recommended by Chicks Master, USA).

 

After completing 456 hours (19 days) in incubator the fertility of eggs was checked through candling process. All the infertile eggs were removed from the tray and just fertile eggs shifted to hatchers for next 50 hours (2 days and 8 hours). Hatch pulling was performed after 506 hours. Upon hatching of all chicks, hatchability percentage was calculated.

 

Poultry House Conditions

 

The chicks from six hatches were delivered to poultry houses through environmentally controlled vehicles (240C temperature and 65% humidity). At farm, chicks of all three groups were offered water and feed ad libitum. Continuous light was supplied during the whole experimental period. The chicks were fed with starter diets from 1 to 10 d (3010 Kcal ME/kg, 22% crude protein), grower diets from 11 to 20 d (3175 Kcal ME/kg, 20% crude protein) and finisher diets from 21 to 35 d of age (3227 Kcal ME/kg, 18% crude protein). The diet was formulated according to the recommendations of the NRC (1994) using WUFFDA formulation software program. Intake of feed and water was taken daily, while body weight and total feed consumed was recorded on weekly basis. Poultry house conditions were same for all experimental groups and were given in Table 1. For ventilation Viper Touch (Big Dutchman, Co., Germany) system was installed.

 

Table 1: Environmental conditions of poultry house

 

Parameters	Week
	1st	2nd	3rd	4th	5th
Temperature (°C)	34-30	30-28	28-25	25-24	24
Humidity (%)	65	65	65	65	65
Ventilation (m3/hour/bird)	0.07	0.25	0.40	0.59	0.87

 

Statistical Analyses

 

All data were analyzed by using Statistical Analysis System package software (SAS version 9.2, SAS Institute Inc., Cary, NC, USA). All means were compared using Duncan’s Multiple Range test and results were presented as mean ± SEM (standard error of mean). Results were considered significant if exist P < 0.05.

 

RESULT AND DISCUSSION

 

After fifteen successful hatches out for individual group, hatchabilities were recorded. Difference in term of hatchability percentage was found for groups A, B and C which was pre-heated for 5 hours, 3 hours and control, respectively. Group A showed better hatchability percentage and the average of fifteen hatches was recorded 87.31% as compared to B (86.68%) and control (85.96%) group (Figure 1A).

 

 

Similarly, difference between groups A and B, B and C and A and C were recorded and shown in Figure 1B. Significant difference (P <0.01) were found between AandC groups (1.339±0.066) as compared to A and B (0.621± 0.059) or B and C (0.71±0.072) groups.

 

During 35 d trail period, mortality, feed intake, weight gain and FCR was recorded and results were presented in Table 2. Interestingly, the effect of pre-warming on broilers performance was also found better as compared to control group. Mortality was reduced significantly (P<0.05) in A (3.18±0.77) and B (3.97±0.63) groups as compared to control (5.39±0.02) group. Weight gain (g/bird) was increased (P<0.01) in A (1955.66±21.82) and B (1896±83.97) groups as compared to control group (1668.33±32.14). Feed conversion ratio (FCR) was found significantly better (P<0.002) in A (1.49±0.06) and B (1.72±0.02) groups than C group (1.91±0.05). However, feed intake (g/bird) was not affected (P> 0.05) by the pre-warming regimen of eggs.

 

Table 2: Post-hatch performance of broilers

 

Parameters	Groups
	A	B	C
Mortality	3.18±0.77a	3.97±0.63a	5.39±0.02b
FCR	1.49±0.06a	1.72±0.02b	1.91±0.05c
Weight gain (g/bird)	1955.66±21.82a	1896±83.97a	1668.33±32.14b
Feed intake (g/bird)	3048.43± 155.84	3179.14± 141.60	3068.87±3.51

 

a, b, c, Denotes significant difference in rows (P<0.05). A: Pre-heated at 82oF for 5 hours; B: Pre-heated at 82oF for 3 hours; C: Without pre-heat treatment (control); FCR: Feed conversion ratio

 

To achieve better hatchability uniform shell temperature is necessary (Renema et al., 2006). Pre-heating is a good tool to avoid condensation that results the improved hatchability (Marandure et al., 2012). Hatchability and hatch window are critical factors to assess the performance of hatchery. Pre-heating provides uniform temperature for growing embryos result more chicks in short hatch window helps to achieve good quality chicks (Tona et al., 2003). Uniform temperature for developing embryos enhances the performance of chicks at farm resulting better FCR and less mortality (Fasenko and O’Dea, 2009).

 

In summary, the findings of current study tended to show that pre-warming to broiler breeder eggs at 82oF for 5 hours enhances the hatchability. Better performance in terms of weight gain and mortality was found for group A and B, while FCR was highest for A than B group, whereas it was poor for control group. Feed intake was same for all groups.

 

ACKNOWLEDGMENTS

 

The authors are thankful to respectable Director of Sadiq Poultry (Pvt) limited Mr. Salman Sadiq and Project Co-ordinator Engr. Jawad Kiwan Qazi for their full support, motivation, fruitful suggestions and encouragement during the whole period of research work. We are also grateful to hatchery supervisor Mr. Muhammad Ashfaq for his cooperation.

 

AUTHORS’ CONTRIBUTION

 

Dr. Adnan Yousaf and Dr. Adnan Jabbar are main authors have equally contribution in this work, while Dr. Yasir Allah Ditta help in analysis data statistically.

 

CONFLICT OF INTERESTS

 

The authors declare that they have no conflict of interest with respect to the research, authorship, and/or publications of this article.

 

REFERENCES

 

Anonymous (2011). Food and Agriculture Organization of the United Nations. FAOSTAT.

FAO (2011). Per capita meat consumption declines by 1.7pc. Food and Agriculture Organization results. Brazil. J. Poult. Sci. 10: 17–22.

Fasenko GM, O’Dea EE (2009). Evaluation broiler growth and mortality in chicks with minor level conditions hatching. Poultry. Sci. J. 87: 594 -597

Hussain J, Rabbani I, Aslam S, Ahmad HA (2015). An overview of poultry industry in Pakistan. World Poult. Sci. J. 71(4): 689-700. https://doi.org/10.1017/S0043933915002366

Khan A, Rind R, Shoaib M, Kamboh AA, Mughal GA, Lakho SA, Malhi KK, Nizamani AR, Yousaf A (2016). Isolation, identification and antibiogram of Escherichia coli from table eggs. J. Anim. Health Prod. 4(1): 1-5. https://doi.org/10.14737/journal.jahp/2016/4.1.1.5

King’ori AM (2011). Review of the factors that influence egg fertility and hatchability in poultry. Indian J. Poult. Sci. 10: 483–492. https://doi.org/10.3923/ijps.2011.483.492

Koka TD (2002). Effect of storage and pre heating during storage on hatchability. Poult. Sci. 12(8): 21-23.

Mahmud A, Khan MZU, Saima, Javed MA (2011). Effect of different storage periods and temperatures on the hatchability of broiler breeder eggs. Pakistan Vet. J. 31: 78–80.

Marandure T, Matondi GH, Nayamushamba GB, Ganyani B (2012). Effect of duration of pre heating broiler breeder eggs on hatchability, egg weight and chick uniformity posthatch. Res. J. Agric. Environ. Manage. 1 (1): 1-5.

Nazia, Malhi KK, Durrani NU, Kamboh AA, Lakho SA, Rind R, Abro SH, Soomro NM (2015). Prevalence of septic arthritis caused by Staphylococcus aureus in poultry birds at Tandojam, Pakistan J. Anim. Health Prod. 3(3): 73-77.

North MO, Bell D (1990). Commercial chicken production manual, 4th edition. Van Nostrand Reinhold, New York, USA.

Renama RA, Feddes JJR, Schunid KL, Ford MA, Kolk AR (2006). Internal egg temperature in response to preincubation warming in boiler breeder and turkey eggs. J. Appl. Poult. Res. 15: 1-8. https://doi.org/10.1093/japr/15.1.1

Reijrink IAM, Meijehof R, Kemp B, Graat EAM, van den Brand H (2009). Influence of prestorage incubation on embryonic development, hatchability and chick quality. Poult. Sci. 88: 2649–2660. https://doi.org/10.3382/ps.2008-00523

Silva FHA, Faria DE, Torres KAA, Faria Filho DE, Coelho AAD, Savino VJM (2008). Influence of egg pre-storage heating period and storage length on incubation of the United Nations (News-agencies 20/02/2010).

Tona K, Malheiros RD, Bamelis F, Careghi C, Moraes VMB (2003). Effects of storage time on incubating egg gas pressure, thyroid hormones, and corticosterone levels in embryos and on their hatching parameters. Poult. Sci. 82: 840–845. https://doi.org/10.1093/ps/82.5.840